A peer-reviewed journal published by K. N. Toosi University of Technology

Dosimetric evaluation of TLD calcium phosphate pellets produced by SPS and PLS sintering methods

Document Type : Research Article

Author

Radiation Application Research School, Nuclear Science & Technology Research Institute, Tehran, Iran

Abstract
This study investigates the thermoluminescent (TL) behavior of calcium phosphate-based ceramic pellets, hydroxyapatite (HAp) and ‎‎β-tricalcium phosphate (‎β‎-TCP), fabricated using two distinct sintering techniques: spark plasma sintering (SPS) and pressureless sintering (PLS). The main objective was to evaluate how the fabrication route and powder origin influence the dosimetric characteristics of these materials. Pellets were prepared from both laboratory-synthesized and commercially obtained powders and irradiated with ‎γ‎-rays from a Co-60 source in the dose range of 20 to 800 Gy. The results revealed that pellets derived from commercial powders exhibited comparable TL responses under both sintering techniques, while those produced from synthesized powders showed notable differences in TL intensity and linear dose-response range. The PLS fabricated pellets displayed improved fading resistance and repeatability, maintaining a more stable TL signal over time compared with their SPS counterparts. The influence of sintering conditions, powder type, and thermal history on the glow curve structure and kinetic parameters was also analyzed through deconvolution. Overall, the findings indicate that the dosimetric response of calcium phosphate ceramics is strongly affected by both the sintering method and the powder origin. Although further investigations using additional radiation sources are required, the obtained results highlight the potential of these materials for high-dose TL dosimetry applications.

Highlights

  • Calcium phosphate pellets were fabricated by SPS and PLS methods.
  • TL response of synthesized powders depended strongly on the sintering route.
  • PLS pellets showed better fading resistance and repeatability.
  • SPS pellets had higher sensitivity but suffered from fading and instability.
  • PLS is recommended as the optimal method for practical dosimetry.

Keywords


Copyright
RPE is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License (CC BY-NC 4.0).

Conflict of Interest
The authors declare no potential conflict of interest regarding the publication of this work‎.

Funding
‎The authors declare that no funds‎, ‎grants‎, ‎or other financial support were received during the preparation of this manuscript‎.

Adachi, M., Bredow, T., and Jug, K. (2004). What is the origin of color on metal complex dyes? Theoretical analysis of a Ni-coordinate azo dye. Dyes and Pigments, 63(3):225–230.
Alvarez, R., Rivera, T., Guzman, J., et al. (2014). Thermoluminescent characteristics of synthetic hydroxyapatite (SHAp). Applied Radiation and Isotopes, 83:192–195.
Anselmi-Tamburini, U. et al. (2019). Spark plasma sintering. In Elsevier Reference Collection in Materials Science and Materials Engineering.
ASTM (2004). Standard practice for using the Fricke reference-standard dosimetry system.
Bhatt, B. C. and Kulkarni, M. (2014). Thermoluminescent phosphors for radiation dosimetry. In Defect and Diffusion Forum, volume 347, pages 179–227. Trans Tech Publ.
Cruz-Zaragoza, E., Marcazzó, J., Ram´ırez, E. P., et al. (2021). Thermoluminescence properties of high-dose gamma-irradiated diamond films. In Journal of Physics: Conference Series, volume 1723, page 012052. IOP Publishing.
Daneshvar, H., Manouchehri, F., Shafaei, M., et al. (2019a). Study on Effects of Hydroxyapatite Synthesis Conditions Using Hydrothermal Method on its Thermoluminescence Response from Dosimetry Viewpoint.
Daneshvar, H., Shafaei, M., Manouchehri, F., et al. (2019b). The role of La, Eu, Gd, and Dy lanthanides on thermoluminescence characteristics of nano-hydroxyapatite induced by gamma radiation. SN Applied Sciences, 1(10):1146.
Daneshvar, H., Shafaei, M., Manouchehri, F., et al. (2020). Influence of morphology and chemical processes on thermoluminescence response of irradiated nanostructured hydroxyapatite. Journal of Luminescence, 219:116906.
Eichholz, G. G. (2003). Dosimetry for food irradiation.
Erabi, M., Ziaie, F., Taghipour, P., et al. (2021). Synthesis of Hydroxyapatite via solid-state method and investigation upon heat treatment and dopant effects on its thermoluminescence response. Journal of Radiation Safety and Measurement, 10(4):1–8.
Isokawa, Y., Kimura, H., Kato, T., et al. (2019). Radiation induced luminescence properties of Eu-doped SiO2 glass synthesized by spark plasma sintering. Optical Materials, 90:187–193.
Kavarian, H., Masoudi, S. F., and Daneshvar, H. (2025). Dosimetric properties of calcium phosphate tablets prepared by spark plasma sintering method. Nuclear Engineering and Technology, 57(9):103632.
Kavarian, H., Mosayebi, A., and Daneshvar, H. (2024). Study on Tablet conversion by pressure-less sintering method on the thermoluminescent dosimetric response of Beta Tricalcium Phosphate. Radiation Physics and Engineering, 5(2):1–10.
Kocjan, A., Bhootpur, N., Ivekovi´ c, A., et al. (2024). Rapid densification of nanocrystalline zirconia: Pressureless versus pressure-assisted spark plasma sintering. Open Ceramics, 19:100657.
Madhukumar, K., Varma, H., Komath, M., et al. (2007). Photoluminescence and thermoluminescence properties of tricalcium phosphate phosphors doped with dysprosium and europium. Bulletin of Materials Science, 30(5):527–534.
Miller, A. (1986). Dosimetry for radiation processing. International Journal of Radiation Applications and Instrumentation. Part C. Radiation Physics and Chemistry, 28(5-6):521–529.
Munir, M. T. and Federighi, M. (2020). Control of foodborne biological hazards by ionizing radiations. Foods, 9(7):878.
Murru, C. (2012). Research about pressureless sintering of milled powder zrb2 based ceramic with carbon. In UNIVERSIT DEGLI STUDI DI PADOVA.
Nakashima, K., Takami, M., Ohta, M., et al. (2005). Thermoluminescence mechanism of dysprosium-doped β-tricalcium phosphate phosphor. Journal of luminescence, 111(1-2):113–120.
PAS ¸CU, A. and Timar-Gabor, A. (2014). Electronic components as luminescence retrospective accident dosimeters. Romanian Reports in Physics, 66(3):853–861.
Shafaei, M., Ziaie, F., and Hajiloo, N. (2016). Thermoluminescence properties of micro and nano structure hydroxyapatite after gamma irradiation. Kerntechnik, 81(6):651–654.
Shafaei, M., Ziaie, F., Sardari, D., et al. (2014). The effect of sintering on thermoluminescence response of hydroxyl apatite nano-structure synthesized via hydrolysis method from dosimetric point of view. Journal of Radiation Safety and Measurement, 3(4):13–18.
Shafaei, M., Ziaie, F., Sardari, D., et al. (2015). Study on carbonated hydroxyapatite as a thermoluminescence dosimeter. Kerntechnik, 80(1):66–69.
Shiratori, D., Kimura, H., Nakauchi, D., et al. (2020). Dosimetric properties of Sn-doped SiO2 glasses synthesized by the spark plasma sintering method. Radiation Measurements, 134:106297.
Sripathy, A. P. and Gupta, M. (2021). Insight into layered metal matrix composites.
Taghipour, P., Zolfagharpour, F., and Daneshvar, H. (2022a). Synthesis of hydroxyapatite through solid-state reaction method and study of its thermoluminesence dosimetric properties against gamma rays. Radiation Physics and Engineering, 3(2):7–10.
Taghipour, P., Zolfagharpour, F., Daneshvar, H., et al. (2022b). Thermoluminescence dose–response of synthesized and doped hydroxyapatite: effect of formed crystal phases. Luminescence, 37(5):742–757.
Taghipour Niar, P., Ziaie, F., Daneshvar, H., et al. (2023). Synthesis of hydroxyapatite doped with single and compound dopants and study upon the effect of crystal phase on its thermoluminescence response irradiated by gamma rays. Journal of Nuclear Science, Engineering and Technology (JONSAT), 44(1):47–57.
Texeira, M. I., Cecatti, S. G., Caldas, L. V., et al. (2008). Performance of thermoluminescent materials for high dose dosimetry.
Zahedifar, M., Sadeghi, E., Harooni, S., et al. (2015). Thermoluminescence dosimetry features of DY and Cu doped SrF2 nanoparticles under gamma irradiation. Applied Radiation and Isotopes, 105:176–181.
Zarinfar, A., Shafaei, M., and Ziaie, F. (2015). Synthesis, characterization and thermoluminescence properties of nano- structure gadolinium doped hydroxyapatite (HAP: Gd). Procedia Materials Science, 11:293–298.
Volume 7, Issue 1
Winter 2026
Pages 11-18

  • Receive Date 21 September 2025
  • Revise Date 16 October 2025
  • Accept Date 24 October 2025